DEVELOPMENT OF HARD POROUS CARBON MATERIALS RB CERAMICS AND EVALUATION OF THEIR TRIBOLOGICAL PROPERTIES

硬质多孔碳材料RB陶瓷的研制及其摩擦性能评价

• 批准号: 10555046
• 负责人: HOKKIRIGAWA Kazuo
• 金额: $ 8.06万
• 依托单位: YAMAGATA UNIVERSITY
• 依托单位国家: 日本
• 项目类别: Grant-in-Aid for Scientific Research (B).
• 财政年份: 1998
• 资助国家: 日本
• 起止时间: 1998 至 2000
• 项目状态: 已结题
• 来源: https://kaken.nii.ac.jp/en/grant/KAKENHI-PROJECT-10555046/
• 关键词: RICE BRAN; RB CERAMICS; FENOL RESIN; FRICTION; WEAR

The aim of this research is to analyze tribological properties of new porous carbon materials "RB ceramics" which is made of defatted rice bran impregnated with phenol resin and carbonized in a vacuum furnace at high temperatures.From the research in 1998, it is obtained that friction coefficient and specific wear rate of RB ceramics decrease with carbonizing temperature, under dry condition, oil impregnated condition or in water.From the research in 1999, it is obtained that a linear slide bearing can be made by using RB ceramics, and it shows low noise because difference of static friction and kinetic friction is very small.From the research in 2000, it is obtained that RB ceramics shows no noise or no severe wear even in high contact pressure, so RB ceramics can be used as new clutch materials.

本文对脱脂米糠浸渍酚醛树脂，真空炉高温炭化制得的新型多孔炭材料“RB陶瓷”的摩擦学性能进行了分析，从1998年的研究结果得出，RB陶瓷的摩擦系数和比磨损率随炭化温度的升高而降低，在干燥条件下，1999年的研究表明，RB陶瓷可以制成直线滑动轴承，由于静摩擦和动摩擦的差别很小，所以噪音很低。2000年的研究表明，结果表明，RB陶瓷在高接触压力下无噪声，无严重磨损，可作为新型离合器材料。

项目成果

K.Hokkirigawa et.al.: "Friction and Wear Properties of New Tribo-Materials "RB Ceramics"Made from Rice Bran"Int.Tribology Conf., 2000.10.30, Nagasaki, Japan. (2000)

K.Hokkirikawa 等人：“由米糠制成的新型摩擦材料“RB 陶瓷”的摩擦和磨损特性”国际摩擦学会议，2000 年 10 月 30 日，日本长崎。

K.Hokkirigawa, Song Chunsheng, K.Imai, A.Matsutani, J.Ando, S.Shikano and T.Takahashi: "Friction and Wear Properties of New Tribo-Materials "RB Ceramics" Made from Rice Bran"Int.Tribology Conf.Nagasaki, Japan. (2000)

K.Hokkirikawa、宋春生、K.Imai、A.Matsutani、J.Ando、S.Shikano 和 T.Takahashi：“米糠制成的新型摩擦材料“RB 陶瓷”的摩擦磨损性能”国际摩擦学会议

K.Hokkirigawa, K.Karube, M.Kudo and Y.Shirata: "Development of New Linear Dry Sliding Bearing by Using RB Ceramics"Int.Tribology Conf.Nagasaki, Japan. (2000)

K.Hokkirikawa、K.Karube、M.Kudo 和 Y.Shirata：“使用 RB 陶瓷开发新型线性干式滑动轴承”国际摩擦学会议，日本长崎。

K.Hokkirigawa: "DEVELOPMENT OF NEW TRIBO-MATERIALS "RB CERAMICS" MADE OF RICE BRAN"Proceedings of the 2nd International Symposium on High Performance of Tribology, Taegu, Korea. 22-27 (1999)

K.Hokkirikawa：“由米糠制成的新型摩擦材料“RB 陶瓷”的开发”第二届高性能摩擦学国际研讨会论文集，韩国大邱。

K.Hokkirigawa, et.al.: "Friction and Wear Properties of New Tribo-Materials "RB Ceramics" Made from Rice Bran"Int.Tribology Conf.Nagasaki.

K.Hokkirikawa 等人：“由米糠制成的新型摩擦材料“RB 陶瓷”的摩擦磨损特性”Int.Tribology Conf.Nagasaki。